VOLVO
CPM-B1D2511 - Heater Fuel Pump. General Electrical Failures. Circuit short to ground
System
Verbrennungsheizung (CPM)
Volvo-Modelle, für die dieser Fehlercode gilt
Gilt für folgende Modelle:
9 ModelleS60 (2011–), S80 (2007–), V40 (2013–), V40 Cross Country (2013–), V60 (2011–), V60 Cross Country (2015–), V70 (2008–), XC60 (2009–), XC70 (2008–)
Modelle nach Baujahr und Motor anzeigen (9)
Was bedeutet der Fehlercode?
The fault code concerns the positive feed to the fuel pump in the auxiliary heater, which has a short to ground, or a signal from the pump that is too low. The control module then switches the heater off. If the heater is activated again, it makes a new start attempt. Common causes are damaged wiring, a short to ground or a faulty pump.
Mögliche Ursachen
- Damaged cable or connection
- Cables short-circuited to ground
- Damaged fuel pump
- Short to ground in the cable between the heater control module and the fuel pump
Was Sie tun können
- 1With the ignition off, check the wiring and connectors between the heater and the fuel pump for damage, looseness or incorrect fitting, and for corrosion.
- 2Check that the earth connection to the heater is firmly attached and clean.
- 3Use a multimeter to check that the positive wire to the fuel pump has no contact with ground (the body). If it does, repair or replace the wire.
- 4Use gloves and safety goggles when working near the fuel pump, as fuel can spill. Disconnect the pump connector and check it for corrosion and looseness.
- 5Replace the fuel pump if its connector is damaged, or have a workshop do it.
- 6If the fault remains after checking the wiring, have a workshop check the fuel pump and the heater control module.
Symptome, die Sie bemerken können3
- Poor heating in the cabin
- The parking or auxiliary heater does not work when it is activated
- The parking heater does not work
Was der Fehler beeinflussen kann2
- The heater is switched off when the fault occurs
- The heater makes a new start attempt if it is activated again
Allgemeine Hinweise für Fahrzeughalter. Die Diagnose am Fahrzeug kann eine andere Ursache zeigen.